How to Install a Mantel on a Stone Fireplace | Ask This Old House

Ask This Old House mason Mark McCullough travels to Chicago to install a wood mantel on a homeowner’s 1980s contemporary fireplace

#ThisOldHouse #AskTOH

SUBSCRIBE to This Old House: http://bit.ly/SubscribeThisOldHouse

Mark McCullough

Time: 3-4 hours

Cost: $300

Skill Level: Difficult

Tools:
Miter saw [https://amzn.to/3b3i05f]
Drill driver [https://amzn.to/35xOgMs]
Tape measure [https://amzn.to/3dvKyGf]
Level [https://amzn.to/2YIx6ut]
Hole saw [https://amzn.to/2W72VLv]
Masonry drill [https://amzn.to/3dvKQgj]
Masonry hammer [https://amzn.to/2W5ZAML]
Socket wrench [https://amzn.to/3dkGl7U]

Shopping List:
Mantel [https://www.bairdbrothers.com/Red-Oak-Contemporary-Box-Mantle-Style-5-BM5-P76892.aspx]
2x4” framing lumber [https://www.homedepot.com/p/2-in-x-4-in-x-104-5-8-in-Prime-Kiln-Dried-Doug-Fir-Stud-179087/202046800]
Framing screws [https://amzn.to/3bdkFtf]
Wedge anchors [https://amzn.to/2W3IejD]
Brass screws [https://amzn.to/2W3ILSF]

Steps for installing a fireplace mantel:
1. Start by assembling a cleat that will be mounted on the face of the fireplace to accept the mantel. This can be done by cutting the 2x4” material with a miter saw to the dimensions of the mantel. Secure the cleat together using framing screws and butt joints.
2. Determine the height of the mantel. Mantels are usually about 54” from the floor. With stone fireplaces, it’s important to find a mostly flat section to securely mount the cleat and the mantel to. it’s possible a stone might stick out proud of the mantel and make it more challenging to mount the cleat. In that case, it usually makes sense to go a little higher.
3. With the height of the mantel identified, determine the center of the fireplace and mark it at the determined height.
4. Determine the center of the cleat and mark it.
5. Hold the center of the cleat up to the center of the fireplace. Place the level on top of the cleat to ensure it’s level. With the cleat still against the fireplace, identify locations to secure the bolts. Depending on the type of stone, it might be safer to pick mortar joints over drilling directly into the stone. Before pulling the cleat back down, check for any bumps in the stone that might make it challenging to secure the cleat and mark those areas on the cleat as well.
6. Cut out any sections of the cleat that were just marked using a hole saw.
7. Drill holes through the marks on the cleat to accept the bolts.
8. Hold the cleat back in place. Drill holes through the cleat and into the fireplace using a masonry drill.
9. Hammer the wedge anchors into the holes and then tighten them in place using a socket wrench.
10. With the cleat secured to the fireplace, slide the mantel onto the cleat.
11. Secure the mantel to the cleat using brass screws.

Resources:
Mark installed the Red Oak Contemporary Box Mantel Style #5 [https://www.bairdbrothers.com/Red-Oak-Contemporary-Box-Mantle-Style-5-BM5-P76892.aspx], which was prestained in Early American and finished in a clear finish. It was provided by Baird Brothers Fine Hardwoods
(https://www.bairdbrothers.com/Mantels-C444.aspx).

Mark used concrete sleeve anchors [https://amzn.to/2W3IejD] to secure the mounting board to the masonry fireplace. These can be purchased at home centers and hardware stores.

About Ask This Old House TV:
Homeowners have a virtual truckload of questions for us on smaller projects, and we're ready to answer. Ask This Old House solves the steady stream of home improvement problems faced by our viewers—and we make house calls! Ask This Old House features some familiar faces from This Old House, including Kevin O'Connor, general contractor Tom Silva, plumbing and heating expert Richard Trethewey, and landscape contractor Jenn Nawada.

Follow This Old House and Ask This Old House:
Facebook: http://bit.ly/ThisOldHouseFB
Twitter: http://bit.ly/ThisOldHouseTwitter
http://bit.ly/AskTOHTwitter
Pinterest: http://bit.ly/ThisOldHousePinterest
Instagram: http://bit.ly/ThisOldHouseIG
Tumblr: http://bit.ly/ThisOldHouseTumblr

Keywords:
This Old House, Ask This Old House, DIY, Home Improvement, DIY Ideas, Renovation, Renovation Ideas, How To Fix, How To Install, How To Build

Watch the full episode:
https://www.thisoldhouse.com/season-18-ask-toh-episodes

How to Install a Mantel on a Stone Fireplace | Ask This Old House
https://www.youtube.com/user/thisoldhouse/

Тэги:

#This_Old_House #masonry #fireplaces #mantel #Mark_McCullough #7-10_minutes #DIY #Construction #Home_Improvement #Ask_This_Old_House #Building #Renovation #Renovation_Ideas #How_To_Fix #How_To_Install #How_To_Build #Stone_Fireplace #diy_ideas #contemporary_fireplace #wood_mantel #Ask_This_Old_House_mason #mason_Mark_McCullough #fireplace_mantel_decor #fireplace_mantel_build #fireplace_mantel_makeover #fireplace_mantel_diy #fireplace_mantel_ideas #fireplace_mantel_installation

Скачать видео